prevention of corner cracks in slab continuous casting.pdf - PDFQueen - PDF Search engine. Free unlimited pdf search and download.

Continuous casting has achieved widespread popularity because it is capable of extracting ..... Prevention of this type of crack clearly can be achieved by maintenance of the ..... corner crack in a slab. 502-VOLUME 8B, SEPTEMBER 1977 ...

http://www.springerlink.com/index/J802735J1V177575.pdf

One defect encountered in continuous-cast semifinished products is the longitudinal ... sence or absence of longitudinal corner cracks at each of the four ...

http://www.springerlink.com/index/W082251HHT777778.pdf

Abstract: The reasons of transverse corner crack in hull structural steel CC (continuous casting) slab have been analyzed in this paper. ...

http://www.vanitec.org/pdfs/1dc46ca22c6e63583dc06b4760159057.pdf

by BG Thomas - Cited by 20

http://ccc.illinois.edu/PDF Files/Publications/01_JKB_webpost.pdf

surface cracks. Quantifying these phenomena requires modeling of both the steel flow and flux layers. .... Prevention of Shell Thinning Breakouts Associated ... of Steel Shell Behavior in the Continuous Slab Casting Mold. ... section through the corner of a continuous-cast steel breakout shell (Moitra and ...

http://ccc.illinois.edu/introduction/Dantz_Ch_rev3.doc.final.pdf

in thin-slab continuous casting. They can be caused by a variety ... off-corner longitudinal cracks, referred to as “Craquelet,” which ...

http://www.aimnet.it/allpdf/pdf_pubbli/feb09/hibbeler.pdf

15.00 Prevention of corner cracks in slab continuous casting. N. Triolet - ArcelorMittal Research, Maizières-les-Metz, France ...

http://www.aimnet.it/allpdf/6ECCC.pdf

Analysis of the Cause and Prevention of Longitudinal Midface Cracks and Depressions on Continuously ... Simulation of Longitudinal Off-Corner Depressions in Continuously ... Production of Continuous Casting Slabs Free From Surface Crack ...

http://steellibrary.com/BookContents/PB-098 1 Table of Contents.pdf

increasing casting speeds. Continuous casting of steel in slab format ... cases may lead to corner cracks. .Sub surface defects arising out of prevention of alumina flotation. . Longitudinal cracking, especially in ...

http://www.foseco-steel.com/steel/downloads/technical_papers/02.pdf

by AJ Moore - Cited by 10

http://www.foseco-steel.com/steel/downloads/technical_papers/10.pdf

by S KITTAKA - Cited by 6

http://www.nsc.co.jp/en/tech/report/pdf/8614.pdf

by M OKIMORI - Cited by 2

http://www.nsc.co.jp/en/tech/report/pdf/n8716.pdf

by S Ogura - Cited by 1

http://www.jfe-steel.co.jp/archives/en/ksc_giho/no.14/e14-023-030.pdf

by H Nakato - Cited by 2

http://www.jfe-steel.co.jp/archives/en/ksc_giho/no.14/e14-031-041.pdf

by HNHAN Young Мок WON - 2000 - Cited by 17

http://engineering.snu.ac.kr/kor/..\pdf\045-Analysis of Solidification Cracking Using.pdf

by K Kim - Cited by 35

http://engineering.snu.ac.kr/kor/..\pdf\017-Analysis of Surface and Internal.pdf

“Occurrence mechanism and prevention method of longitudinal surface cracks near slab corner in continuous casting”, JSME. International Journal, Series A, ...

http://ieeexplore.ieee.org/iel5/5202889/5203125/05203172.pdf?arnumber=5203172

In continuous casting process, due to the cooling slab ... vibration, often produce surface crack, crack Corner, star cracks and so on. According to statistics, the major ..... Prevention and Practice Development,.Iron making and Steel ...

http://ieeexplore.ieee.org/iel5/4700820/4730505/04730598.pdf?arnumber=4730598

of off-corner cracks and the breakouts in the solidifying ..... model for steel behavior in continuous slab casting, 76th Steelmaking ...

http://www.iop.org/EJ/article/1468-6996/2/1/A50/STAM_2_1_A50.pdf

Control of delivery of molten steel in continuous casting is critical in order ..... [9] Tai H, Morishtia M and Miyake T 1998 Prevention of longitudinal cracks due to uneven solidification at slab corner by optimization of submerged nozzle 3rd European. Conf. on Continuous Casting pp 447–54 ...

http://www.iop.org/EJ/article/0957-0233/12/8/320/e10820.pdf

by FR Camisani-Calzolari - 2002 - Cited by 2

http://www.nt.ntnu.no/users/skoge/prost/proceedings/ifac2002/data/content/00300/300.pdf

by O Sjoden - 2007risk of corner cracks, longitudinal cracks, breakouts, quarter-band inclusions, mould powder entrapments and surface defects in slab casting. ...

http://scindeks-clanci.nb.rs/data/pdf/0354-6306/2007/0354-63060701011S.pdf

bloom/slab casters help in avoiding continuous casting machine is ..... longitudinal corner crack induced casting powder of low viscosity and ...

http://www.steelworld.com/technology0309.pdf

by BG THOMAS - 2002 - Cited by 20

http://www.brimacombecourse.org/pdf/2001_Thomas.pdf

File Format: PDF/Adobe Acrobatby FR Camisani-Calzolari - 200324 Jan 2008 ... Formation of off-corner internal cracks in continuously-cast billets. .... Prevention of surface crack formation in continuous cast slab. ...

http://upetd.up.ac.za/thesis/available/etd-01242008-122052/unrestricted/07references.pdf

Transversal corner cracks These cracks occur on the radiused or ..... B) liquid slag layer thickness in continuous slab casting of SUS 321 ... powder usage are therefore essential as an initial step in the prevention of inclusions'. ...

http://upetd.up.ac.za/thesis/available/etd-01242008-122052/unrestricted/02chapter2.pdf

transversal cracks. Origins of transversal corner cracks exist in a ... The defects in cast slab and blooms are deoxidation products, droplets or fragments of mold ... 2)Prevention of nozzle clogging to keep the role of SEN as designed .... Targets in the continuous casting technology in near future are2>: ...

http://www.postech.ac.kr/ticm/education/short/2000/00-lecture-A12-5.pdf

Thin slab caster. As shown in. Fig. 44), the continuous casting .... surface. Corner crack. Longitudinal or transverse crack .... 2) Prevention of grain growth after each cycle of recrystallization: otherwise the refining effect is ...

http://www.postech.ac.kr/ticm/education/short/2000/00-lecture-A12-1.pdf

by B Tambunan - Related articles

http://komputasi.inn.bppt.go.id/semiloka06/Barman_Tambunan.pdf

Most types of cracks occurring during continuous casting of steel are ... corner cracks along dendrite boundaries perpendicular to the surface should be the ..... correlated to longitudinal surface cracks in slabs [31]. .... Y. Aketa and K. Ushijima, Study on the Mechanism of the Occurrence and the Prevention of ...

http://www.informaworld.com/index/775996915.pdf

section on 'prevention of Diagonal Cracks in Beams'. •Published jointly in 1964 by the American .... face to provide similar support for the corner. A load test of a floor slab with cracked area ... spacing, and consist of six 67 ft continuous spans, the ... and so anchored in, with cast-in-place gypsum roof slabs. ...

http://www.informaworld.com/index/792179983.pdf

The exact taper of the mold narrow faces in continuous slab casters ... breakout prevention system as well as a heat flux and friction monitoring .... The adjustment of the taper has severe effects on longitudinal and corner cracks. ...

http://www.metal2010.com/data/metal2005/sbornik/papers/221.pdf

by R Villoría - Cited by 3

http://www.siderurgia.org.ar/pdf/108.pdf

by C Genzano - Cited by 3

http://www.siderurgia.org.ar/pdf/39.pdf

Modelling of the Steel/Slag Interface in a Continuous Casting. Tundish. ... From Slab Corner Cracks to Edge-Defects in Hot Rolled Strip ...

http://www.stahleisen.de/html/zeitschriften/files/steel_research_annual_index_of_publications_2008_english.pdf

responsible for surface quality issues like corner cracks, and internal defects like hot tearing ... of steel slab continuous casting has been developed by ...

http://publish.edpsciences.com/articles/metal/pdf/2005/05/P343.pdf

by JX Li - 2007 - Cited by 1

http://www.secat.net/docs/resources/Fatigue_of_Continuous_Cast07.pdf

by C Siyasiya - Related articles

http://www.saimm.co.za/Journal/v105n07p473.pdf

A defect free slab, bloom or beam blank and an economical operation are the objectives to be achieved by ... the air pressure versus the water flow in continuous casting .... transverse and corner cracks. Because of the convergence of ...

http://www.environmental-expert.com/Files\2778\articles\12850\17.pdf

by M Schueren - 2007 - Cited by 2

http://www.castrip.com/technical/pdf/01/The Castrip Process An Update on Process Development at Nucor Steel's First Commerical Strip Castring Facility 6-07.pdf

ability; (2) for break out, longitudinal and corner cracks- improvements of mold flux, ... prevention of contaminations of the molten steel such as .... principles of continuous casting are remarkable. 6.1. Thin slab casting ...

http://iopscience.iop.org/1468-6996/2/1/A17/pdf/1468-6996_2_1_A17.pdf

prevention or control of cracking in concrete construction. .... compared with identical concrete cast on a draining base, ... Temperature and shrinkage cracks in unreinforced slabs-on- ..... continuous slot in the slab to result in a weakened plane, .... 3.13—Diamond-shaped load plates at slab corner. ...

http://www.concrete.org/General/f302.1(04)Chap3.pdf

CONTINUOUS CASTING OF STEEL: MODELLING, SIMULATION, OPTIMISATION,. EXPERIMENTS. Bošidar Łarler ... ACRONI (1997-2001) Modernisation of Slab Caster ... no cracks no porosity desired composition desired structure. Process: safety productivity .... Caseter Segments Temperatures Overview - Centerline, Corner, Average ...

http://fluid.ippt.gov.pl/sarler/AMAS_MOD_CC_STEEL.pdf

Over the life span of a continuous casting machine the requirements in terms of ... If a crack defect is detected in a slab at 40mm depth below the surface, .... In these casters corner cracking occurs mainly when casting narrow ...

http://www.lechler.de/pdf/audits_secondary_cooling.pdf

by JW Frick - Cited by 2

http://www.lechlerusa.com/pdfs/frickarticle.PDF

continuous grouted joints. This watermark does not appear in the registered version ... Corner cracks could occur at columns. ∎ Sawcuts at end of bars would help ... moisture condition of slab. ∎ Check for air when casting cylinders ...

http://www.obec.on.ca/EVENTS/PDF-Feb-2009/Concrete Floors - Understanding what can cause grief.pdf

by MR Allazadeh - 2009 - Related articles

http://etd.library.pitt.edu/ETD/available/etd-01162009-125011/unrestricted/M_R_Allazadeh(Jan-2009).pdf

26 Oct 2009 ... BOF or EAF: Distribution of nuclides, monitoring, prevention. ISIJ International 45 ..... crack formation in the continuous casting of low-alloyed copper. Proc. .... continuously cast slabs. 4th European Continuous Casting Conference, Birmingham, ..... Zn in the copper - rich corner of the systems. ...

http://materials.tkk.fi/fi/tutkimusryhmat/2009-10-26-public_mtg.pdf

of the trowel and flatten the ridges to form a continuous, even coat of material. ... Ready-to-use, elastomeric, waterproofing and crack prevention ... slab-on-grade moisture barrier for resilient flooring installa- .... CAST IRON DRAIN WITH CLAMPING RING FOR. THIN-SET APPLICATION WITH WEEP HOLES. FULLY SUPPORTED ...

http://products.construction.com/swts_content_files/2170/E219835.pdf

—Automatic Assessment of the Severity of Cracks in Steel Tubes Using ..... Continuous Casting Slabs,“ 79th ISS Steelmaking Conference, Pittsburgh, ... C. Cicutti, J. Petroni, G. Di Gresia, M. Dziuba, and E. Lagos, —Transverse Corner ...

http://www.wfndec.org/CINI Document.pdf